Technical discussion thread - Kawasaki Rouser 135 LS-DTSi

[CYCLEHAWK]

sana pinagbuksan mo ng pinto para hinde na sya kumatok. hehehe!

kaya siguro kumakatok gusto lumabas men. kamote, commuter na naman ako nito!
bili kaya ako ng bagong LS?

ride safely...

[abet135ls]

men, according to my own experience, you have to report it to your dealer or better yet go to KAWASAKI Plant to address your problem directly & promptly, yun nga lang men
kelangan maaga ang pagpunta mo dun. kasi kapag pinakialaman mo ang motor nila, nila
ha eh baka ma void ang mga warranty men.

MEn share ko lng din own experience ko ako tumawag muna ako sa dealer ko pra ipaalam ko n my cra ang motor ko pero d n ko pumunta dun tinanung ko lng kung pede dun ko n mismo papagawa kesa sa kanila since n nasa akin nmn un waranty notebook ko pina deretsyo n ko sa kawasaki alabang mxado p kc maraming kwento pag sa dealer k nag cmula prang kung anu anu p eexplain sau pero sa huli wala dn cla maggawa sakin lng iwas sa sayng n oras.

[novic07]

men, medyo mabigat ang problema kasi pinakita nya sa akin yung piston ang bumigay @ antay mode muna ako sa development.

ride safely...

♣Bumigay ung piston? Nabutas ba ung piston nya bro?

[abet135ls]

update on my KBR-LS135

went to kawa service ctr @ caloocan beside CYCLEMAR this am & the mechanic showed me that the piston is the culprit, the question is how? according to the mechanic, possible
cause due to the heat of the engine & by installing a belly pan deters the flow of air to the engine (what???!!!), and to my recollection this is the rainy season (official trip sa Lucaban-Quezon summer time hindi bumigay, ngayon pa?), i was amazed how intelligent the mechanic was so i asked if the belly pan is placed under the engine how could this effect the engine block? (nasa ilalim nga ng tank yung block?) again there are other factor he uttered. In order that my mc could be repaired & the part be replaced, i, the owner, have to submit a letter in which the content is what happened, how often i use the bike, why did i use a gear to make my bike fast, why did i not go to them for a check-up, etc. i asked him, what is the warranty coupon for? (sigh)...tsk tsk tsk.

sana may naka assign sa kawa service ctr na pwedeng sumagot na katulad ni s' Arnel
na straight to the point @ my sense kausap.

ride safely...KBR rules...

MEn chelax k lng mas maganda kung ppalitan mo n yun buong makina mo kung bumigay n pla mga pyesa nito mea meron p ibng bumigay dyan n ndi nakita ng mga magagaling n mechanic, covered nmn yan men wala k nmn ginalaw sa makita or upgrade ng makina report mo sa kawasaki e2 no.8423140 loc 352 try to look for mr.cabantog service manager yan men yan ok kausap at cguradong my actions ka.

Lupit ng diagnose sau hehehe.

[novic07]

update on my KBR-LS135

went to kawa service ctr @ caloocan beside CYCLEMAR this am & the mechanic showed me that the piston is the culprit, the question is how? according to the mechanic, possible
cause due to the heat of the engine & by installing a belly pan deters the flow of air to the engine (what???!!!), and to my recollection this is the rainy season (official trip sa Lucaban-Quezon summer time hindi bumigay, ngayon pa?), i was amazed how intelligent the mechanic was so i asked if the belly pan is placed under the engine how could this effect the engine block? (nasa ilalim nga ng tank yung block?) again there are other factor he uttered. In order that my mc could be repaired & the part be replaced, i, the owner, have to submit a letter in which the content is what happened, how often i use the bike, why did i use a gear to make my bike fast, why did i not go to them for a check-up, etc. i asked him, what is the warranty coupon for? (sigh)...tsk tsk tsk.

sana may naka assign sa kawa service ctr na pwedeng sumagot na katulad ni s' Arnel
na straight to the point @ my sense kausap.

ride safely...KBR rules...

♣Ang talino ng mechanic na yan bro ah? Hehe.. Belly pan mo pa pinagdiskitahan.. Yan ung mga mechanic na basta lng may maturo na dahilan.. Sa tingin ko bro mas maganda nga na tawagan mo ung sinabi ni abet.. Good luck bro.. ™

[Toy Toy]

update on my KBR-LS135

went to kawa service ctr @ caloocan beside CYCLEMAR this am & the mechanic showed me that the piston is the culprit, the question is how? according to the mechanic, possible
cause due to the heat of the engine & by installing a belly pan deters the flow of air to the engine (what???!!!), and to my recollection this is the rainy season (official trip sa Lucaban-Quezon summer time hindi bumigay, ngayon pa?), i was amazed how intelligent the mechanic was so i asked if the belly pan is placed under the engine how could this effect the engine block? (nasa ilalim nga ng tank yung block?) again there are other factor he uttered. In order that my mc could be repaired & the part be replaced, i, the owner, have to submit a letter in which the content is what happened, how often i use the bike, why did i use a gear to make my bike fast, why did i not go to them for a check-up, etc. i asked him, what is the warranty coupon for? (sigh)...tsk tsk tsk.

sana may naka assign sa kawa service ctr na pwedeng sumagot na katulad ni s' Arnel
na straight to the point @ my sense kausap.

ride safely...KBR rules...

Naku... very bad yan Men, sana wag na mangyari sa iba Men., nakaka lungkot kasi wala na kami spear head at marshal pag umuuwi, sana maayos yan kasi dumadami na tayo kaya sana lahat masaya. saka pano nangyari yun eh bago pa lang naman unit mo Men, wala pa naman taon diba?

[sciwerx888]

gud pm po. Rouser 135 ls owner din po ako.. gusto ko po sana mag join sa RCP. Taga Marilao Bulacan po ako

[sciwerx888]

malapit dun sa nka super four sir,

------------------------ Posts Auto Merged------------------------

may ride po bh tyo dis saturday s marilaque? (sunday kasi may bagyo n daw)

sir bloodyvalentine. gusto ko po sana mag join sa RCP. taga Marilao, Bulacan po ako. nka rouser 135ls po ako. paano po ako maka-join?tnx and ride safe

[novic07]

gud pm po. Rouser 135 ls owner din po ako.. gusto ko po sana mag join sa RCP. Taga Marilao Bulacan po ako

♣Welcome to RCP bro.. Tambay ka sa tambayan bro para makilala ka namin at makilala mo rin mga kabrousers naten pati na ng mga baby nila at kung my tanung ka din regrding sa ls135 mo eh masagot ng mga masters naten.. Looking forward to meet you sa tambayan bro.. Every wednesday sa j. vargas-C5 sa shell bro at every Saturday naman sa the fort malapit sa St. Lukes Hospital sa shell din.. ™

[kokiks28]

gud pm po. Rouser 135 ls owner din po ako.. gusto ko po sana mag join sa RCP. Taga Marilao Bulacan po ako

http://www.motorcyclephilippines.com...d.php?t=249714

ayan sir RCP Bulacan chapter sir kung malayo sayo ang J. Vargas at d Fort...

[csrbiker]

ilan na odo mo sir? may mods ka ba ginawa? kinalikot mo ba ang A/F?

7000km na sir jo, wala naman akong binago as a/f mixture bigla na lang bumagal last week, ramdam mo sa pag pull ng throtle eh.

[hulk001]

update on my KBR-LS135

went to kawa service ctr @ caloocan beside CYCLEMAR this am & the mechanic showed me that the piston is the culprit, the question is how? according to the mechanic, possible
cause due to the heat of the engine & by installing a belly pan deters the flow of air to the engine (what???!!!), and to my recollection this is the rainy season (official trip sa Lucaban-Quezon summer time hindi bumigay, ngayon pa?), i was amazed how intelligent the mechanic was so i asked if the belly pan is placed under the engine how could this effect the engine block? (nasa ilalim nga ng tank yung block?) again there are other factor he uttered. In order that my mc could be repaired & the part be replaced, i, the owner, have to submit a letter in which the content is what happened, how often i use the bike, why did i use a gear to make my bike fast, why did i not go to them for a check-up, etc. i asked him, what is the warranty coupon for? (sigh)...tsk tsk tsk.

sana may naka assign sa kawa service ctr na pwedeng sumagot na katulad ni s' Arnel
na straight to the point @ my sense kausap.

ride safely...KBR rules...

belly pan?.. Parang hrap naman paniwalaan nun.. Mga mag kan0 daw damages lahat?

Sakin lang sir ah..tingin ko jan mali ang break in m0.. Skin hard breakin din first 200km pina 100kph ko na agad ng hindi sagad bawat gear.. Tapos change oil agad..

sir matan0ng ko lang hard break in b gnawa m0? Bka masyad0ng nhrapan m0tor mo.. Oil

[PATZZZ14]

new decals...carbonn fiber...and white stripes....

[hulk001]

mga sir ano kaya problema sa rouser ko, lately di na lumalagpas ng 75kph yung motor ko, ano kaya problema? Dati kc ramdam ko na lalagpas pa ng 100kph eh, ramdam ko yung hatak kahit sagad na yung gear. Any ideas or suggestions?

nag palit kaba ng tires? Bka po masyad0ng malaki ung kinabit m0.. kaya naka apekto sa accuracy ng speedo (front) or mabigat (rear)..

Tsaka ung valve clearance bka masyad0ng maluwag na.. Pa tune up mo na sir.

[eidxof]

men dito ka na lang dumaan sa east ave. den left turn ka sa corner ng Heart Center Matalino Road @ tumbok nung kalsada na yun eh kalayaan ave. men.

ride safely...KBR rules...

sige sir ito na lang gagawin ko.. dami hepa boys sa kalayaan.. dun na alng ako sa east ave daan..


@sir Novic, baka nga sir kaw yun eh sumenyas din.. so far kabrouser malamang... red rouser akin black helmet. pillion si misis with red helmet...

ride safe brothers.. sa sat try ko punta sa tambay. sino po pd mkasabay? kaw po sir novic?

[eidxof]

nag palit kaba ng tires? Bka po masyad0ng malaki ung kinabit m0.. kaya naka apekto sa accuracy ng speedo (front) or mabigat (rear)..

Tsaka ung valve clearance bka masyad0ng maluwag na.. Pa tune up mo na sir.

di kaya sir palyado na ang isang SP mo.. nabasa ko toh sa isang nagpost dito.. way back.. natabunan na post nun... check SP sir. baka di na gumagana isa..

[novic07]

sige sir ito na lang gagawin ko.. dami hepa boys sa kalayaan.. dun na alng ako sa east ave daan..


@sir Novic, baka nga sir kaw yun eh sumenyas din.. so far kabrouser malamang... red rouser akin black helmet. pillion si misis with red helmet...

ride safe brothers.. sa sat try ko punta sa tambay. sino po pd mkasabay? kaw po sir novic?

Ok lng bro.. San ka ba manggagaling bro? Ako kasi maggagaling pa sa office.. Pero for sure sa paguwi marami tayong mgkakasabay.. Musta po pala rouser nyo bro? Wala ka ba naman naging probleam?

[xreaper]

new decals...carbonn fiber...and white stripes....

Sir pats may pagawaan ka ba ng decals? Palit ka ng palit e, hehe

Anyway amfogi ng decals mo ngaun, kainggit, papm naman ng inabot nyan

[novic07]

mga sir ano kaya problema sa rouser ko, lately di na lumalagpas ng 75kph yung motor ko, ano kaya problema? Dati kc ramdam ko na lalagpas pa ng 100kph eh, ramdam ko yung hatak kahit sagad na yung gear. Any ideas or suggestions?

Bro ty mo linisin ung spark plugs mo tsaka ung air cleaner mo.. Baka madumi na kaya mejo nawala hatak ng mc mo bro.. Pero kung ganun padin, dalhin mo nlng sa mechanic ng dealer mo bro or sa kawa plant na mismo for them to check ur mc's problem..

[eidxof]

Ok lng bro.. San ka ba manggagaling bro? Ako kasi maggagaling pa sa office.. Pero for sure sa paguwi marami tayong mgkakasabay.. Musta po pala rouser nyo bro? Wala ka ba naman naging probleam?

so far ok na ok ang performance ng rouser.. haven't thought of a name yet.. haha...
isa lang naging prob ko.. kahapon sa commonwealth, bigla pumugak takbo ko.. yun pala reserve na dapat.. di nmn nag blink yung light na kelangan ko na mag switch to reserve.. buti na lang nakatabi ako agad then switch to reserve..

ayun.. naka 250km na odo.. next week na first change oil.. meron shop dun sa may montalban highway. .sabi may shop daw sila sa caloocan din.. dun na lang ako nag order ng elf mineral oil... kayo sir novic ano masusuggest nyo na oil?

about sa tambay po.. may pasok ako ng 8pm.. dito ako sa cubao... siguro pd ako sumaglit dun sa tambay.. sama tayo kung pd...

[eidxof]

Bro ty mo linisin ung spark plugs mo tsaka ung air cleaner mo.. Baka madumi na kaya mejo nawala hatak ng mc mo bro.. Pero kung ganun padin, dalhin mo nlng sa mechanic ng dealer mo bro or sa kawa plant na mismo for them to check ur mc's problem..

Sir novic.. question po.. gano kadalas ba dapat linisin ang air cleaner? since maalikabok sa dinadaanan ko, malamang baka mangyari din sakin problem sa hatak...

[eidxof]

mga sir ano po masusugest nyo na panlinis sa rouser natin?

yung nabasa ko dito. matagal ng post, gamit nya armor all? kayo mga brothers ano po gamit nyo? at magkano nmn kaya sila?

[jojo_ph]

7000km na sir jo, wala naman akong binago as a/f mixture bigla na lang bumagal last week, ramdam mo sa pag pull ng throtle eh.

Ok so kung wala ka binago sa mc mo, madami na din nasabi mga kasama natin dito, check the SP, aircleaner, baka mali nailagay mo na viscosity ng langis (masyadong malapot) or pwede din na sobra masyado langis mo. Check the valve clearance, malaki epekto nito. Worst case po, ang CDI mo, sa pagkakaalam ko may tatlong timing maps cdi natin (not sure but most cdi's does have several timing maps and is sequentially activated depende sa rpm).

[jhon16]

pano po ba iadjust ang a/f mixture?

[rjsigno]

mga master... nagpalit ako ng LED color blue dun sa park light sa harapan ganda ng effect kaso after two days pundi agad ung isa... question... ano po ba maganda LED or ung stock na peanut bulb? may nabibili bang peanut bulb na color blue? saan? and saan makakbili nga super yellow na head light?...

...ung socket ng headlight ng Rouser natin ay 3 pareho s kotse... pede ba tyo gumamit ng pang kotse na ang wattage ay mataas sa 35/35w?
patulong naman mga masters, i want to improve more the lights of my Rouser... thanks ng many many...